The Influence of Type of Solvent and Extraction Temperature of Corn Silk Extracts

- Haslina, Novizar Nazir, Sri Budi Wahjuningsih, Dewi Larasati

Abstract


Corn silk has not been well-utilized.  Actually it has the capacity to develop into functional food because it contains bioactive compounds and high natural antioxidant such as flavonoids and phenolics and positive effects on human health. There are several factors that influence the quality of corn silks extracts, including ratio (raw:solvents) and extraction temperature. This research was couducted to determine the influence of ratio (raw:solvent) and extration temperature of corn silk extracts.  The experimental design used Randomized Block Design (RBD) which consisted of two factors and 3 replications. The first factor was type of solvent. All treatment use (raw:solvents) ratio at (1:4). The first factor consists P1=raw:ethanol (1:4)(w/v), P2=raw:methanol (1:4)(w/v), P3=raw:ethyl acetate (1:4)(w/v), and P4=raw:acetone (1:4)(w/v). and the second factor was extraction temperature that consists S1=60°C, S2=70°C, and S3=80°C. Data were analyzed with analysis of variance, followed by Duncan Multiple Range Test (DMRT) test at 5% significant level. Parameters of chemical analysis were included (water, ash, protein, fat, and carbohyrate), and phytochemical analysis were included (total phenol, total flavonoid, activity antioxidant, beta carotene, and vitamin C). The results showed that the type of solvent  and extraction temperature of corn silk extracts have significantly effect on water, ash, protein, fat, and, total phenol, total flavonoid, activity antioxidant, beta carotene, and vitamin C. Methanol solvent and extraction temperature at 60°C is the best treatment which have the highest protein and the lowest fat content at 18.22%±1.13 and 0.17%±0.02 respectively, and  the highest total phenol, total flavonoid, activity antioxidant, beta carotene, and vitamin C at 8216.89±132.39 μgGAE/g; 234.29±3.98 μgGAE/g; 215.27ppm±3.87; 80.80%±1.84; and 8.84%±0.45 respectively. 


Keywords


local corn silk; extract; type of solvents); extraction temperature.

Full Text:

PDF

References


J. Guo, T. Liu, L. Han, and Y. Liu. The effect of corn silk on glycaemic metabolism. Journal of Nutrition and Metabolism Biomed Central, vol. 6, p.47. 2009.

Haslina, D.Praseptiangga D, V.P. Bintoro, B.Pujiasmanto. Chemical and phytochemical characteristics of local corn silk powder of three different varieties. International Journal of Advanced Science Engineering Information Technology 7 (5) p: 1957-1963. 2017.

Distantina. Larutan perendaman terhadap kecepatan ekstraksi dan sifat gel agar-agar dari rumput laut Gracilana verrulosa. Jurnal Rekayasa Proses 2:11-16. 2008.

K.K. Chew, S.Y. Ng, Y.Y Thoo, M.Z.. Khoo, W.M Wan Aida, and C.W Ho. Effect of ethanol concentration, extraction time, and extraction temperature on the recovery of phenolic compounds and antioxidant capacity of Centella asiatica extracts. International Food Research Journal 18:571-578. 2011.

H.Handayani and F.H. Sriherfyna.. Ekstraksi antioksidan daun sirsak metode ultrasonik bath (kajian rasio bahan:pelarut dan lama ekstraksi). Jurnal Pangan dan Agroindustri 4(1) p:262-272. 2016.

Y.Mukraini. Ekstraksi, pemisahan senyawa identifikasi senyawa bioaktif. Jurnal Kesehatan 7(2) p:361-367. 2014.

D.T. Wahyuni dan S.B. Widjanarko. The effect of different solvent and extraction time of carotenoids extract from pumpkin with ultrasonic Jurnal Pangan dan Agroindustri 3(2) p:390-401. 2014.

J. Tong-Wei, X Jian, W. Xiao-Meng, C. Xue-Song, and Q Zhi-Dong. Screening of active ingredient of stigmata maydis inhibitor xanthine oxidase and its effect. Journal of Jilin University Medicine Edition 37(3):433-436. 2011.

A.R. Nurhanan, W.I.W. Rosli, and S.S.J. Mohsin. Total polyphenol content and free radical scavenging activity of corn silk (Zea mays hairs). Sain Malysiana 40 (2) p:155-161. 2012.

M.L. Bangora, J. Nsor-Atindana, and Z.H. Ming. Solvent optimization extraction of antioxidants from foxtail millet species’ insoluble fibers and their free radical scavenging properties. Food Chem 141 p:736-744. 2013.

G..K Jayaprakasha, R.P. Singh, and K.K. Sakariah. Activity antioxidant of grape seed (Vitis vinera) extracts on peroxidantion models in vitro. Food Chem 73 (3) p:285-290. 2001.

B. Vayupharp and V. Laksanalamai. Rocovery of antioxidants from grape seeds and its application in fried. J.Food Processing & Technology. 2012.

A. Selcuk, O. Ozden, and N. Erkan. Effect of frying, grilling, and steaming on amino acid composition of marine fishes. J. Med. Food 13(6) p:1524-1531. 2010.

Y.G. Purwaningdyah, T.D.Widyaningsih, and N.Wijayanti. Efektivitas ekstrak biji pepaya sebagai antidiare pada mencit. Jurnal Pangan dan Agroindustri 3(4) p:1283-1293. 2015.

Q. L. Hu, L. Zhang, J. Li, Y. N. Ding, and F. L. Li. Purification and antifatigue activity of flavonoids from corn silk, International Journal of Physical Sciences, vol 5 p:321-326. 2011.

Association of Official Analytical Chemist (AOAC). Official method 980.17 preservatives in ground beef spectrophotometric method. USA:AOAC International. 2007.

E. Candesa and L. Parker. Handbook of Antioxidant. 2nd ed., New York, NY: Marcell Dekker Inc. 2002.

J. Liu, C. Wang, Z. Wang, C. Zhang, S. Lu, and J. Liu. The antioxidant and free-radical scavenging activities of extract and fractions from corn silk (Zea mays L) and related flavone glycosides, Food Chemistry vol. 126 p:261-269. 2011.

N.Yinusa, I. George, R.G. Ayo, and Y. Rufai. Vacuum liquid chromatographic isolation and characterization of beta-sitosterol from the bark of Sarcocephalus latifolius (Smith Bruce), Journal of Chemistry and Chemical Sciences 5 (9) p:480-488. 2015.

E.Kurniati. Pembuatan konsentrat protein dari biji kecipir dengan penambahan HCl. Jurnal Penelitian Ilmu Teknik 9(2) p:115-122. 2009.

N.S.Palupi, F.R. Zakaria, dan E. Prangdimurti. The effect of processing on the nutritional value of food. Topic 8. ENBP e-learning module. Department of Food Science and Technology Fateta-IPB. Bogor. 2007.

D.Wazir, A.Syahida, M.Radzali, M.Maziah, and M.Y.Shukor. Antioxidant activities of different parts of Gnetum gnemon L. Journal Plant Biochemistry and Biotechnology. 2011.

B. Sultana, F. Anwar, and Przybylski. Activity antioxidant of phenolic components in bark of Azadirachta indica, Terminalia arjuna, Acacia nilotica dan Eugenia jambolana Lam trees. Food Chemistry 104 p:1106-1114. 2007.

Rivai, I. W.R.Widarta, dan K.A. Nosianitri. Pengaruh jenis fenolik dan aktivitas antioksidan ekstrak biji alpukat (Persia americano Mill). Jurnal ITEPA 7(2) p:22-32. 2018.

A.M. Ibrahim, Yunita, dan H.S. Feronika.Pengaruh suhu dan lama waktuekstraksi terhadap sifat kimia dan fisik pada pembuatan minuman sari jahe merah dengan kombinasi penambahan madu sebagai pemanis. Jurnal Pangan dan Agroindustri. 3 (2) p:530-541.2015.

S.Lenny. Senyawa flavonoid, fenilpropanoida dan alkaloida. Fakultas MIPA, USU. 2006.

L.Y.Qiao, R.Sun, Chen, Y.Fu, W.Zhang, X.Li, J.Chen, Y.X.Shen, and Ye. Sonochemical effects on 14 flavonoids common in citrus. Relation to stability. Plos ONE 9 (2):e87766. 2014.

A.Miryati, L.Sapei, K.Budiono, dan S.Indra. Ekstraksi antioksidan dari kulit buah manggis (Garcinia mangostana L). Universitas Katolik Parahyangan, Bandung. 2011.

C. Perwiratami, M.Suzery, and B.Cahyono.Korelasi total fenolat dan total flavonoid dengan antioksidan dari beberapa sediaan ekstrak buah tanjung (Mimusoup elengi) 7(1) p:34-38. 2014.

S.Ogawa. Studies on Activity antioxidant in Japanese Edible Seaweeds. Tesis. Tokyo University of Fisheries, Tokyo. 2003.

H. Rivai, E.Widiya, and Rusdi. The effect of comparison of ethanol-water treatment areas of total phenolate compounds and power antioxidants of extract of sirsak leaf (Annona muricata L.). Fakultas Farmasi Universitas Andalas, Padang, Jurnal Sains dan Teknologi Farmasi 18(1) p:35-42. 2013.

A.M. Legowo, Nurwantoro, dan Sutaryo. Analisis Pangan. Fakultas Peternakan Universitas Diponegoro, Semarang p:22-24. 2005.

S.J. Padayatty, A.Katz, Y.Wang, and M. Levine. Review vitamin C as an antioxidant: evaluation of its role in disease prevention. Journal of the American College of Nutrition 22:18-35. 2003.




DOI: http://dx.doi.org/10.18517/ijaseit.9.3.9037

Refbacks

  • There are currently no refbacks.



Published by INSIGHT - Indonesian Society for Knowledge and Human Development